低排放燃烧室NOx排放试验及预测方法研究

doi:10.13675/j.cnki. tjjs. 015

推进技术 ›› 2019, Vol. 40 ›› Issue (12): 2766-2774.DOI: 10.13675/j.cnki. tjjs. 015

低排放燃烧室NO_x排放试验及预测方法研究

何沛¹,邓向阳¹,鄂亚佳¹,徐榕¹,张弛^2,3,林宇震^2,3

1.中国航发商用航空发动机有限责任公司，上海 200241;2.北京航空航天大学能源与动力工程学院航空发动机气动热力国家级重点实验室，北京 100191;3.先进航空发动机协同创新中心，北京;100191

发布日期:2021-08-15
基金资助:
国家自然科学基金 91641109国家自然科学基金（91641109）。

NOx Emission Test and Prediction Method for Low Emission Combustor

1.AECC Commercial Aircraft Engine Co. Limited,Shanghai 200241,China;2.National Key Laboratory of Science and Technology on Aero-Engine,Aero-Thermodynamics,School of Energy and Power Engineering,Beijing University of Aeronautics and Astronautics,Beijing 100191,China;3.Collaborative Innovation Center for Advanced Aero-Engine,Beijing 100191,China

Published:2021-08-15

摘要/Abstract

摘要： 为了研究中心分级贫油低排放燃烧室的排放特性和排放预测方法，针对一个低排放头部方案，在单头部燃烧室试验件上，在不同的温度、压力、油气比、供油模式和分级比条件下，测量其排放性能。以Lefebvre排放经验预测公式为基础，采用经验分析方法拟合排放试验数据，归纳出适用于本头部方案的排放预测公式。表征预测好坏的判定系数R²在小工况下和大工况下分别为0.95和0.93，表明预测结果与试验结果符合度较好。小工况和大工况排放特性不同，对仅预燃级喷油的小工况工作模式，NO_x排放主要受化学恰当燃烧温度和预燃级局部当量比的影响；对预燃级和主燃级同时喷油的大工况工作模式，NO_x排放主要受燃烧区温度和主燃级燃油比例的影响。

关键词: 航空发动机;排放试验;排放预测;贫油燃烧;分级燃烧;燃油分级

Abstract: Better understanding of emission behavior and emission prediction method for central staged lean low emission combustor are needed. Low emission combustor was tested on a single injector combustor test rig. Emission was measured under varied temperature, pressure, fuel air ratio, fuel split mode and pliot fuel proportion. Empirical method based on Lefebvre equation was used to analyze the emission data, and emission prediction method suitable for present injector was recommended. Coefficient R² for prediction effect judgement are 0.95 and 0.93 for low power and high power, respectively. Good prediction effect compared with experiment was obtained. Emission behavior at low power and high power state are different. At low power state with pliot fuel only, NO_x emission are influenced mainly by stoichiometric flame temperature and pilot zone equivalence ratio. At high power state with both pilot fuel and main fuel, NO_x emission are influenced mainly by combustion zone temperature and main fuel ratio.

Key words: Aero-engine;Emission test;Emission prediction;Lean combustion;Staged combustion;Fuel stage

何沛,邓向阳,鄂亚佳,徐榕,张弛,林宇震. 低排放燃烧室NO_x排放试验及预测方法研究[J]. 推进技术, 2019, 40(12): 2766-2774.

HE Pei¹,DENG Xiang-yang¹,E Ya-jia¹,XU Rong¹,ZHANG Chi^2,3,LIN Yu-zhen^2,3. NOx Emission Test and Prediction Method for Low Emission Combustor[J]. Journal of Propulsion Technology, 2019, 40(12): 2766-2774.

参考文献

[1] Lefebvre A H. Fuel Effects on Gas Turbine Combustion-Liner Temperature, Pattern Factor， and Pollutant Emissions[J]. AIAA Journal of Aircraft， 1982， 21（11）： 887-898.
[2] Rizk N K， Mongia H C. Emissions Predictions of Different Gas Turbine Combustors[R]. AIAA92-0118.
[3] Rizk N K， Smith D A. Regional and Business Aircraft Mission Emissions[R]. ASME 92-GT-300.
[4] Odgers J， Kretschmer D. The Prediction of Thermal NO_x in Gas Turbine[R]. ASME 85-IGT-126.
[5] Danis A M， Pritchard B A， Mongia H C. Empirical and Semi-Empirical Correlation of Emissions Data from Modern Turbopropulsion Gas Turbine Engines[R]. ASME 96-GT-86.
[6] Facchini B， Ferrara G， Mazzilli P. A Semi-Analytical Approach to Emissions Prediction in Gas Turbine Combustors[R]. ASME 98-GT-216.
[7] Zelina J， Penko P F. Low-Emissions Gas Turbine Combustor Development for Regional-Class Aircraft[R]. ASME2000-GT-0100.
[8] Ikezaki T， Hosol J， Toh H， et al. The Performance of The Low NO_x Aero Gas Turbine Combustor under High Pressure[R]. ASME2001-GT-0082.
[9] Allaire D L， Waitz I A， Willcox K E. A Comparison of Two Methods for Predicting Emissions from Aircraft Gas Turbine Combustors[R]. ASME GT2007-28326.
[10] Laviolette M， Perez R. On the Prediction of Pollutant Emission Indices from Gas Turbine Combustion Chambers[R]. ASME GT2012-70038.
[11] Musaefendic H， Mery Y， Noel T. An Uncertainty Quantification Framework Coupled with A 1D Physics-Based Model for the Prediction of NO_x Emissions in A Rql Combustion Chamber[R]. ASME GT2015-23268.
[12] Rokke N A， Hustad J E， Berg S. Pollutant Emissions from Gas Fired Turbine Engines in Offshore Practice Measurements and Scaling[R]. ASME 93-GT-170.
[13] Feitelberg A S， Tangirala V E. Reduced NO_x Diffusion Flame Combustors for Industrial Gas Turbines[R]. ASME2000-GT-0085.
[14] Kroniger D， Wirsum M， Horikawa A， et al. NO_x Correlation for an Industrial 10MW Non-Premixed Gas Turbine Combustor for High Hydrogen Fuels[R]. ASME GT2016-56189.
[15] Lauer M， Farber J， Reib F， et al. Model Based Prediction of Off-Design Operation Condition NO_x Emission from DLE Gas Turbine Combustors[R]. ASME GT2017-63063.
[16] Yousefian S， Bourque G， Monaghan R F D. Review of Hybrid Emissions Prediction Tools and Uncertainty Quantification Methods for Gas Turbine Combustion Systems[R]. ASME GT2017-62271.
[17] Rizk N K， Mongia H C. A Semianalytical Emission Model for Diffusion Flame， Richlean， and Premixed Lean Combustors[R]. ASME 93-GT-128.
[18] Li Lin， Lin Yuzhen， Fu Zhenbo， et al. Emission Characteristics of a Model Combustor for Aero Gas Turbine Application[J]. Experimental Thermal and Fluid Science， 2016， 72: 235-248.
[19] International Civil Aviation Organization. International Standards and Recommended Practices， Environmental Protection ， Annex 16 to the Convention on International Civil Aviation: Volume II Aircraft Engine Emissions[S]. Montreal: International Civil Aviation Organization， 1981.
[20] Wang B， Zhang C， Lin Y Z， et al. Influence of Main Swirler Vane Angle on the Ignition Performance of TELESS-II Combustor[R]. ASME GT2016-56762.
[21] Mi X， Zhang C， Wang B， et al. Influence of Main Stage Air Splits on the Ignition Performance of TELESS-II Combustor[R]. ASME GT2017-63216， .
[22] 王智勇，王波，韩啸，等. TeLESS II低排放燃烧室预燃级设计对排放的影响[J]. 航空动力学报， 2017， 32(7): 1561-1568.
[23] 付镇柏，林宇震，张弛，等. 中心分级燃烧室预燃级燃烧性能试验[J]. 航空动力学报， 2015， 30(1):26-52.
[24] 李海涛，许全宏，付镇柏，等. 中心分级燃烧室预燃级贫油熄火性能试验[J]. 航空动力学报， 2012， 27(9): 2188-2192.
[25] 秦皓，丁志磊，李海涛，等. LESS燃烧室非定常旋流流动[J]. 航空动力学报， 2015， 30(7): 1566-1575.

低排放燃烧室NO_x排放试验及预测方法研究

NOx Emission Test and Prediction Method for Low Emission Combustor

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价